A/C vent air volume not blowing strong.

[nimrod.sixty9]

I have been able to compare my Kon to another, all original, Suburban. The Burb has much better air flow than my Kon. But my evap and drain is as clean as it can be and the blower is new. I can hear its working well but the flow doesnt match the sound; if that makes any sence. Ideas?

99 kon

 

[Danzigman]

Does your Yukon have the A/C air filter under the pass side dash? It may be clogged.

 

[nimrod.sixty9]

Does your Yukon have the A/C air filter under the pass side dash? It may be clogged.

Don't think so, at least Ive never seen it. Also, Im OBS.

 

[BirchyBoy]

I've noticed that my '99 is noticeably stronger when I'm not set to max A/C and the recirculate button is deactivated. I need to poke around to see if there is an inlet somewhere under the dash that is plugged. Does yours act this way?

 

[nimrod.sixty9]

I've noticed that my '99 is noticeably stronger when I'm not set to max A/C and the recirculate button is deactivated. I need to poke around to see if there is an inlet somewhere under the dash that is plugged. Does yours act this way?

I dont believe so. If I remember correctly everything stepped up as it should. Low to hi, increases; recirc, increases. Just not as much pressure. I hope I explained that in a way others can understand

 

[_Dylan_]

in my experience the air flow in the OBS trucks is friggin weak.

 

[SunlitComet]

When you bought the blower was the fan new as well and were they the same angles? Cage fan blade wise?

 

[nimrod.sixty9]

in my experience the air flow in the OBS trucks is friggin weak.

But I have compared to another OBS, one of whoch I would be extreamely satisfied with.

When you bought the blower was the fan new as well and were they the same angles? Cage fan blade wise?

All new, and at quick glance, they looked the same.

 

[SunlitComet]

Then check the air box for leaks. ALso forgot to ask does this happen in all output modes or specific ones?

 

[dsteele]

My 96 does the same thing. Sounds like it's blowing down the walls but not that much air coming out. I've noticed i get a little air coming from the dash and floor vents, so I'm wondering if the blend doors are acting up. Also i've noticed that my center dash vent doesn't turn quite enough to hit dead on the driver ( stupid design )